Product ID:SKD-LT SPOTCHECK DEVELOPER
MSDS Date:07/02/1985
FSC:6850
NIIN:01-265-7234
MSDS Number: BGRXR

MAGNAFLUX DIV OF ILLINOIS TOOL WKS INC

3624 WEST LAKE AVENUE
GLENVIEW, IL 60025
US

Emergency Phone: 847-657-5300/800-424-9300(CHEMTREC)

Info Phone: 847-657-5300 / 5338 (FAX)

Cage: KO362

MAGNAFLUX DIV OF ILLINOIS TOOL WKS INC

GLENVIEW, IL 60025 US

Telephone: 847-657-5300 / 5338 (FAX)

Cage: KO362

METHYLENE CHLORIDE (SARA III)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 90.0%

OSHA PEL 500 PPM/C,1000; Z2

ACGIH TLV: 50 PPM, A2; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 05.0%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IRRITATES EYES MODERATELY
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS SUSPECTED
CARCINOGEN.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION; INGESTION:NOT NOTED BY MFR.
Medical Cond Aggravated by Exposure:SIMULTANEOUS ACCUMULATION OF CARBON
MONOXIDE IN THE BLOOD,AS FROM RECENT EXPOSURE TO COMBUSTION GAS.

First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING
WATER,AND GET MEDICAL ATTENTION.

Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS CAN BURST IF HEATED ABOVE
130F(54.4C).VAPORS PARTIALLY DECOMPOSE TO TOXIC GASES WHEN EXPOSED
TO FLAMES.

Spill Release Procedures:LESS THAN ONE QUART:WIPE UP BUT DO NOT BREATHE
VAPORS;ONE QUART OR MORE:WEAR ALL PERSONAL SAFETY EQUIPMENT TO
AVOID VAPOR/LIQ CONTACT OR BREATHING.EVACUATE UNPROTECTED
PERSONS.ELIMINATE IGN SOURCES.DI KE LIQ.PLACE IN COVERED DRUMS.SEND
TO RECLAIMER.
Neutralizing Agent:NOT NOTED BY MFR.

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES TO
MINIMIZE THE DANGER FROM EXPOSURE TO FIRES.STORE IN
DRY,COOL,VENTILATED AREA.
Other Precautions:DO NOT USE AROUND FLAMES/RED HOT SURFACES.DO NOT HEAT
ABOVE 130F.AVOID BREATHING VAPORS.AVOID FREQUENT/PROLONGED EXPOSURE
TO SKIN.

Respiratory Protection:WEAR RESPIRATOR WITH CHEMICAL CARTRIDGE.IN
CONFINED AREAS,WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW 350PPM OF TLV LIMIT.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Other Protective Equipment:USE IN SPRAY BOOTH OR NEXT TO AN EXHAUST
VENT TO CARRY VAPORS AWAY FROM OCCUPIED AREAS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING MATERIAL.LAUNDER
CONTAMINATED CLOTHES BEFORE REUSE OF SKD-LT DEVELOPER.
Supplemental Safety and Health
MIL-I-25135,REV D,TYPE I,FORM D,NSN;I/A/W QPL-25135-15,SUPPLIER MAY
SUPPLY EITHER SKD-LT OR ZP-9E DEVELOPER UNDER THIS NSN.FLAMMABLE
DEVELOPERS IN AEROSOL CANS NOT APPROVED BY THE SPECIFICATION FOR TH
IS NSN.THIS ENTRY DESCRIBES SKD-LT DEVELOPER.

HCC:G1
Boiling Pt:B.P. Text:N/R(AEROSOL
Spec Gravity:1.3 (OF LIQUID)
Evaporation Rate & Reference:0.7 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THIN,WHITE LIQUID BEFORE FILLING IN AEROSOL CANS.
Percent Volatiles by Volume:90%

Stability Indicator/Materials to Avoid:YES
ALKALI METALS
Stability Condition to Avoid:HEAT/HIGH TEMPERATURES
Hazardous Decomposition Products:PHOSGENE,HYDROCHLORIC ACID GAS,&
OXIDES OF CARBON

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #F002;MAY BE
SENT TO SOLVENT RECLAIMER.INSURE THAT AEROSOL CANS ARE EMPTY AND
DEPRESSURIZED BEFORE DISCARDING,UNLESS A WASTE TREATMENT FACILITY
IS APPROVED TO ACCEPT THEM AS IS.COMPLY WITH FED,ST,& LOCAL REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.